Aircraft News Weblog

Category: Air travel

  • Singapore Airlines B777 Fire on Landing

    Singapore Airlines Flt SQ368 to Milan returned to Singapore Changi airport after a low oil indication on the right hand engine. The crew handled the return by the book and the aircraft landed with no issues and to a round of applause from the 222 passengers on board. However, the applause was short lived as it became apparent the right hand wing was fully engulfed in flames. Remarkably the passengers and crew remained on board and calmly waited for the emergency services to extinguish the flames before disembarking via a set of steps! This would not have been believable in a work of fiction but there a videos from the aircraft passengers who passed the time recording the event through the aircraft windows. Kudos to them and the crew for not rushing into an uncertain mass evacuation and possible injury at the first sign of danger. I can  only assume the crew were following the instructions of the emergency services to remain on board. The following is a media release from the Civil Aviation Authority of Singapore. 

    Media Release

    27 Jun 2016

    CAAS Media Statement on Singapore Airlines (SQ368) Incident

    Early this morning, SQ368, a Singapore Airlines (SIA) B777 aircraft bound for Milan, chose to return to Singapore as the indicator for its right engine had shown oil loss.
    Shortly after landing, a fire was observed to have occurred in the vicinity of the aircraft’s right engine. Changi’s Airport Emergency Service, which was already on standby, responded promptly and the fire was extinguished within 5 minutes. SATS also contributed to ensuring the safety of the passengers and flight crew. No one was hurt during the incident.
    The runway on which the aircraft landed was closed for about 5 hours for repairs and clean-up. Landings and take-offs continued on the other runway. Whilst some flights were impacted, all flights were able to take off within one hour of their scheduled departure times.  
    CAAS will be investigating to determine the causes of the incident. The Ministry of Transport’s Air Accident Investigation Bureau will also be conducting an independent investigation.  

  • Spirit Airlines Pressurization Problems

    A Spirit Airlines flight out of Detroit was forced to turn back shortly after takeoff on Friday due to possible loss of cabin pressure, the airline said.

    Flight 417 took off at about 6:30 a.m. local time from Detroit Metropolitan Airport en route to Fort Lauderdale-Hollywood International Airport in Fort Lauderdale, Florida, Spirit Airlines said in a statement.

    Not long after takeoff, the flight turned back to the airport and landed safely “following a possible loss of cabin pressure,” it said. No injuries were reported.
    It was not immediately clear what had indicated a loss of cabin pressure or exactly how long into the flight the issue became evident. Airline officials were not immediately available to provide additional details.
    People identifying themselves as passengers on the flight posted photographs of themselves to social media with bright yellow oxygen masks affixed to their faces. The masks, which prevent the lightheadedness and unconsciousness cabin pressure loss can result in, are typically deployed during cabin pressure issues.

    (Reporting by Laila Kearney; Editing by James Dalgleish)

  • Dreamliner Nightmare.

    Dreamliner fire at Heathrow.

    How much bad luck can an aircraft type have before the orders dry up and the the public wont fly on it? The one thing which can kill an aircraft is the tendency to have fires. The public will not want to be on an airliner which is periodically filling with smoke.

    When this aircraft concept was announced many years ago I knew that this would be a unique design and be, to use the over worked cliche, cutting edge.There would be huge challenges with the extensive use of composites, the reduction of traditional, proven hydraulic systems and the complete exclusion of the use of bleed air from the engines. All of these were completely different from the traditional method of constructing and operating an airliner.

    There were numerous set backs in the development which raised costs into billions of dollars. Then after the aircraft went into service the aircraft lithium ion batteries failed to operate correctly resulting in a worldwide grounding of the Dreamliner. With this problem resolved, but not solved, we now find ourselves with a fire in an Ethiopian Airlines aircraft at Heathrow which is being attributed to the ELT, the device which transmits an emergency location signal when triggered by a high G situation. This problem, if proven, is as unique as the aircraft due to the scarcity of any other incidents related to this component. The most common failure is an unintentional transmission due to a faulty ELT, but a fire is not something that anyone can recall being reported before.

    I hesitate to mention it but the ELT is powered by lithium ion batteries and that could really be the only source of power to start a fire. The British investigators have now called for all B787 ELT’s to be removed or set inert during the investigation.

    The technology in the Dreamliner is unique and Boeing are taking the lead, and the hits, for this innovation. Maybe, like Concorde before it, the Dreamliner will be a fantastic one off airliner when all the problems are resolved. There is no doubt that composite will be used in other aircraft, but the extensive use of new electrical systems will need more development before other manufactures jump on that band wagon.

    I can only imagine the stress being felt in the boardroom of Boeing in Seattle but I think there is nothing left to do but work with the regulators and get this Boeing going.

  • Asiana Airlines Boeing 777 crash at San Francisco

    There is a lot of information and conjecture coming out in the press regarding the reason the Boeing 777 hit the sea wall during the attempted landing at San Francisco. There will be a definite answer from the NTSB when the investigation is completed which could take months to finalize. Regardless of any mechanical or electronic failures in the aircraft that may have contributed to the crash, the investigation will consider the Human Factors involved. There are always human factors involved and they go well beyond the crew and the circumstances of this particular flight.

    The NTSB will construct a timeline for each crew member going back at least 72 hours. This will include all rest and work periods, medications or personal events which could influence concentration or mood. Crew interaction will be examined to ensure the appropriate actions were not affected by personalities in the cockpit. There will be an examination of the distractions and circumstances in regard to the approach into the airport, and also any distraction warnings or unusual circumstances within the aircraft during the flight.

    It seems to be common knowledge that there was training taking place in the cockpit during the flight. Training of the ‘pilot flying’ during the approach to San Francisco will be examined to assess the amount of supervision provided by the training Captain. This is particularly important as the responsibility to maintain the safety parameters lies with the training Captain if there is a departure from Standard Operating Procedures or erosion of safety limits.

    The reasons for this crash will be many and varied as the Human Factors reach into all aspects of the Asiana Airlines operation of the aircraft in their fleet. The reason could cross all types of aircraft and operations so lessons will be learned and changes and improvements made to prevent this type of accident occurring again in all airlines and operators.

  • B787 Dreamliner battery fix?

    There is some progress in the Boeing 787 Dreamliner battery problems. Boeing have given the FAA full details of a fix for the Lithium Ion battery overheating problem. Although the details are being kept under wraps, the fix has to include a new container for the battery which will prevent damage to the aircraft in case of fire and a method of venting fumes outside. There also has to be a redesign of the wiring or monitoring system to prevent the battery overheating in the first place.

    Further investigation in Japan, where both All Nippon Airways and JAL have had battery incidents on their Dreamliner’s, has resulted in wiring problems being discovered connecting the APU and the Aircraft main battery. The details of these problems are still being investigated and reported to Boeing.

    The original problem with the battery has not been discovered so all possible causes have been identified and fixes proposed to address them. The real test will be when the aircraft starts operating again as there is only so much that can be simulated on the ground or by controlled test flights.

    A long term fix may be the change of the battery type but nobody is talking about that.

    The update from the NTSB that was published in December 2014 blamed the battery problem on the design and possible manufacturing issues with the batteries. The blame was spread between the FAA and Boeing for not considering the consequences or even possibility of a battery cell overheating and affecting other cells. The manufacturing process was also targeted with foreign material found to be introduced into the batteries.

  • Airbus A350-900

    A350-900

    Airbus are reporting there will be no delay to the production and testing schedule of the A350 due to the problems with Lithium-Ion (Li-on) batteries.

    While Boeing are searching for a solution with the B787 Dreamliner battery problems Airbus are pressing ahead with then A350 and have replaced the planned Li-on batteries in favour of the more common Ni-Cad type.There are a number of problems with being the ‘first’ to use new technology and Boeing have taken on the brunt of the problems with the Dreamliner.

    Airbus have been developing their own twin engined wide bodied challenger to the B777 and B787 in the A350. This is the first step into the new technology of extensive carbon fibre for Airbus who are using it as the main component in the fuselage and the wings. This will allow a fuel saving to compete with Boeing on the non stop long distance routes from Europe to Australia and New Zealand.

    Although I would need a good vacation after a London to Sydney 19 hour non stop flight. It is amazing that Bleriot only managed the first crossing of the English Channel in an aircraft from England to France in 1909, around 25 miles, and in 1989 a Qantas B747 completed a non stop flight from London to Sydney 10,500 miles as a publicity stunt.

    Something that would not have helped Bleriot is the engine developed for the A350, which weighing in at just over 6 tonnes would have been bit much for his aircraft!

    The Trent XWB-84 has completed all certification and is being shipped to Toulouse from Rolls Royce for installation. This engine will produce up to 84,000 lbs of thrust required for the first A350-900 which will be completing the flight testing of the aircraft design. Changes to the thrust of the engine will power the other two variants of the aircraft. The increased thrust for the A350-1000 will be achieved by increasing the core engine power, temperature and fan speed rather than the diameter of the engine. Due to this approach nearly 80% of the line replacement units will be common to the engine variants.

    The A350 is scheduled to start flight testing this summer and for those who would like to keep informed of developments here is a link http://www.a350xwb.com/#

  • Dreamliner

    The Boeing 787 Dreamliner has had a most unfortunate couple of weeks. There has been the worst publicity that any aircraft could have. An inflight fire or smoke in the cabin are the worst case scenario for aircrew and the public when it comes to air travel.

    I have avoided the temptation to jump on the band wagon as I have had the experience of working on an newly introduced aircraft type. There is no test like the daily operation of an aircraft, or any vehicle, to bring out a number of problems that the designer and regulatory authorities have not thought of. The Dreamliner has taken this to a whole new level with the type of problem and the world wide grounding of the fleet. If that wasn’t bad enough then the timeline of not only the fix but understanding the cause is seeing the confidence of the carriers fade away.

    There is only so much that the airlines can put up with before the shareholders make the decision to abandon the aircraft and look elsewhere in the competitive world of aircraft supply. Not only that but all the time the airlines are not flying the Dreamliner’s they already operate, the bills are piling up and the lawyers are lining up.

    The battery on the aircraft is touted as the source of the problem,which is ironic as it is there to solve problems when the normal power generation is not operating. This is not the first time this type of battery has given trouble. Cessna had them removed from the new Citation. In that case there was an off the shelf replacement which they could switch to. But it is my understanding that the Dreamliner batteries are so specific to the aircraft that a replacement is not possible in the short term. The whole aircraft is such a new concept that they are breaking ground in many aspects of the systems on board.

    I love the innovation and cutting edge development. But I think they had too much faith put into the battery type without a ‘plan B’. Lets hope the investigation comes to a successful conclusion soon for the sake of the company and the travelling public.

  • Air Canada Rouge

    Only a month after Westjet launch their Regional Airline in June 2013, Air Canada are starting their new vacation airline from the hubs of Toronto and Montreal. The promise is the vacation starts as soon as you board the aircraft.

    Initially starting with surplus aircraft drawn from the Air Canada fleet, the growth of Rouge is reported to be linked to the introduction of the Boeing 787 Dreamliner to Air Canada which will free up more aircraft for the Rouge fleet. The total Rouge fleet will number 50 aircraft when complete and Air Canada are not anticipating delays in fleet growth due to the electrical problems the Dreamliner is experiencing at the moment.

    The key to Rouge succeeding in a highly competitive vacation market is by cutting costs, which the unions have agreed to, by paying the crews less than crews at Air Canada. Another economy is up to 20% more seats on the aircraft to increase the profit margin of every flight.

    For more information regarding Air Canada Rouge try this link, http://www.aircanada.com/en/about/rouge.html

  • Westjet Encore

    Westjet have announced their first plans to enter the Regional Airline business. The new airline is called Westjet Encore and they will be using Bombardier Q400 aircraft.They are starting by connecting Fort St John and Nanaimo toVancouver and Calgary. This is a natural expansion for Westjet as they will now have a feeder airline to bring passengers to larger centres for onward flight with Westjet. These new routes start in June and they are also starting a Victoria to Vancouver service for less than $100 each way. For more information on the new routes try this link http://www.westjet.com/guest/en/deals/offers/summer-schedule.shtml

  • Air Canada Low Cost Carrier

    Where is Air Canada going with the new low cost carrier they are launching? I don’t mean geographically but in terms of their competition. Is there a niche for a low cost airline operating out of Canada and who are they competing against for your travel dollars? How are they going to differ from the present airline? Well, when they come into service, using 50 aircraft of the present Air Canada fleet, there will be a lot more seats on the aircraft and lower pay for the employees to make the model work.

    The natural competition will be other Canadian based carriers operating to the Caribbean, US and Europe. This means Air Canada as well but this is nothing new for them. They are supplying their regional partner Sky Regional with Embraer aircraft on the corridor route between Toronto and Montreal which competes with Air Canada Jazz.

    The theory with the new low cost airline is to attract the type of passenger that wants to pay less than an Air Canada ticket for a flight to a vacation destination. They are hoping to remove passengers from Westjet, Air Transat, Canjet and other carriers that feed the holiday market.

    An announcement coming soon from Air Canada will give more details of the new airline.